Tailored Stapled SADI-S: Initial Report and Preliminary Results

Background and Rationale With obesity rates increasing globally, metabolic and bariatric surgery (MBS) has emerged as the most effective long-term treatment for severe obesity and its related comorbidities such as type 2 diabetes mellitus, hypertension, dyslipidemia, and obstructive sleep apnea. Among the various procedures, laparoscopic sleeve gastrectomy (LSG) and Roux-en-Y gastric bypass (RYGB) have been the most frequently performed worldwide. However, the field continues to evolve with the introduction of newer, simplified techniques that aim to achieve optimal weight loss and metabolic control with lower complication rates and better nutritional safety profiles. Single-Anastomosis Duodeno-Ileal Bypass with Sleeve Gastrectomy (SADI-S), first described by Sánchez-Pernaute and Torres in 2007, is a simplified derivative of the biliopancreatic diversion with duodenal switch (BPD-DS). This operation combines the restrictive component of sleeve gastrectomy with a single duodenoileal bypass, eliminating one anastomosis compared with the traditional DS. By preserving the pylorus, SADI-S maintains the physiological passage of food and minimizes dumping syndrome, postprandial hypoglycemia, and bile reflux. Initially, the common channel length was set at 200 cm but was later extended to 250-300 cm to reduce the risk of excessive malabsorption and protein-calorie malnutrition. SADI-S has since demonstrated excellent outcomes in terms of weight loss, diabetes remission, and comorbidity improvement, with acceptable nutritional safety when the bypassed segment is appropriately chosen. The International Federation for the Surgery of Obesity (IFSO) and the American Society for Metabolic and Bariatric Surgery (ASMBS) have both recognized SADI-S as a validated bariatric procedure. However, despite the growing evidence base, the optimal limb length configuration remains controversial. Most studies use fixed bypass lengths without accounting for wide interindividual variability in total small bowel length (SBL), which can range from 350 to over 1000 cm. Because SBL strongly influences caloric absorption and nutritional outcomes, a "one-size-fits-all" approach may lead to imbalanced results-either inadequate weight loss or excessive malabsorption. Measurement inconsistencies, different starting points for limb calculation, and frequent omission of total SBL assessment further complicate standardization. Tailoring the bypass limb as a proportion of the measured total bowel length may yield more physiologically balanced results and reduce nutritional complications. Despite concerns that intraoperative measurement prolongs surgery, experienced laparoscopic surgeons can measure SBL efficiently, adding only a few minutes to operative time. Another point of technical variation in SADI-S relates to the anastomotic technique. The duodeno-ileal anastomosis is technically more demanding than gastrojejunal anastomoses performed in RYGB or OAGB because of the thin duodenal wall and proximity to the pancreas and bile duct. While both hand-sewn and stapled techniques are described, stapled anastomosis is increasingly favored for its reproducibility, shorter operative time, and lower reported rates of leakage and stenosis. Study Rationale This prospective observational study aims to evaluate a tailored, stapled SADI-S technique in which the length of the biliopancreatic limb (BPL) is calculated as a fixed percentage (35%) of each patient's measured total small bowel length. By tailoring the limb to each patient's anatomy, the study seeks to optimize outcomes by achieving a balance between sufficient weight loss and nutritional safety. To our knowledge, this is the first single-center study to systematically assess outcomes using this formula-based approach in stapled SADI-S. Study Objectives Primary Objective: To evaluate the impact of bypassing approximately 35% of the measured total small bowel length on weight loss, nutritional outcomes, and postoperative symptoms in patients undergoing SADI-S (either as a primary or revisional procedure). Secondary Objectives: To assess the safety and practicality of using a stapled duodeno-ileal anastomosis in all patients. To analyze correlations between the tailored BPL length and outcomes such as comorbidity remission, postoperative symptoms, and quality of life. To assess long-term sustainability of weight loss and rates of nutritional deficiency. Study Design This is a prospective, single-center, observational study conducted at the Department of Surgery, El Sahel Teaching Hospital, Cairo, Egypt. The study will include 40 adult patients who meet the inclusion criteria and provide informed consent. Participants will undergo either primary SADI-S or revisional SADI-S after previous sleeve gastrectomy, depending on individual indication. All surgeries will be performed by experienced bariatric surgeons using a standardized five-port laparoscopic approach. Preoperative Assessment All candidates will undergo thorough preoperative evaluation, including: Complete medical history and physical examination. Anthropometric measurements: height, weight, BMI. Laboratory testing: fasting glucose, HbA1c (for diabetics), CBC, liver and renal function tests, coagulation profile, thyroid function, and micronutrient baseline panel. Cardiopulmonary assessment with ECG and echocardiography. Upper abdominal ultrasound to detect gallstones; concomitant cholecystectomy will be performed when indicated. For revisional cases, CT virtual gastroscopy and gastric volumetry to assess sleeve anatomy, pouch volume, and exclude twist or stenosis. Surgical Technique 1. Patient Positioning and Setup The operation will be performed laparoscopically using a standard five-port configuration. The patient is positioned in the French (split-leg) position with reverse Trendelenburg tilt. 2. Sleeve Gastrectomy Component In primary cases, a 50 French bougie is used for calibration, with complete fundus mobilization and linear stapling from the antrum to the angle of His. In revisional cases, complete adhesiolysis and pouch resizing are performed, again calibrated over a 50 French bougie. 3. Intraoperative Measurement of Small Bowel Length The total small bowel length (TSBL) is measured from the ligament of Treitz to the ileocecal valve. Two atraumatic bowel graspers marked at 5 and 10 cm intervals are used to measure the bowel in fully stretched segments, counting hand-by-hand. Markings are placed at 150 cm and 200 cm with clips and sutures to facilitate later localization. The measurement is typically completed within 8-10 minutes. 4. Tailoring of Bypass Limb The biliopancreatic limb (BPL) is tailored to equal approximately 35% of the TSBL. For patients with TSBL ≤ 480 cm, a fixed 300 cm common limb is retained to avoid malnutrition. For longer TSBL, the duodeno-ileal anastomosis is created at the point corresponding to 65% of the measured total length from the ileocecal valve. 5. Duodeno-Ileal Anastomosis (Stapled Technique) The duodenum is transected 3-4 cm distal to the pylorus using a linear stapler. The selected ileal segment is brought in an isoperistaltic orientation. A side-to-side, functional end-to-end stapled anastomosis is performed using a 45-mm linear stapler. The common enterotomy is closed with a single layer of absorbable running suture. Air-leak test is performed routinely. 6. Completion Hemostasis is confirmed. Drain placement is selective. Specimen extraction is performed through the umbilical or left upper port. Postoperative Management All patients follow a standardized postoperative pathway: Early ambulation within 6 hours after surgery. Liquid diet started on postoperative day 1 and advanced as tolerated. Discharge typically occurs on postoperative day 2-3. All patients receive lifelong vitamin and mineral supplementation as per international bariatric guidelines. Follow-Up Schedule Patients are evaluated at: 1, 3, 6, 9, and 12 months postoperatively, then annually. At each follow-up, data collected include: Weight, BMI, and percent excess weight loss (%EWL). Comorbidity evaluation (diabetes, hypertension, dyslipidemia, sleep apnea, PCOS). Nutritional laboratory profile (Hb, albumin, vitamin D, calcium, phosphorus, magnesium, ferritin, vitamin B12). Assessment of gastrointestinal symptoms (reflux, diarrhea, flatulence, dumping, bile reflux). Quality of life assessment and dietary adherence. Outcome Measures Primary Outcomes: Weight loss effectiveness at 6 months, 1 year, and annually thereafter. Incidence of postoperative gastrointestinal symptoms. Secondary Outcomes: Nutritional outcomes and their correlation with bypassed bowel length. Resolution rates of metabolic comorbidities. Safety and feasibility of the stapled duodeno-ileal anastomosis technique. Data Collection and Analysis All data will be recorded in a prospective electronic database. Weight loss metrics will be analyzed using %EWL and %TWL. Nutritional markers will be compared across time points and correlated with limb length ratios. Complications will be classified according to the Clavien-Dindo scale. Continuous variables will be expressed as mean ± SD and analyzed using paired or unpaired t-tests as appropriate. Categorical variables will be analyzed using chi-square tests. Statistical significance will be set at p \< 0.05. Potential Risks and Benefits The surgical risks are consistent with standard laparoscopic bariatric procedures and include bleeding, leakage, infection, bowel obstruction, and nutritional deficiencies. However, tailoring the bypass length to individual bowel anatomy is expected to lower the risk of severe malabsorption while maintaining adequate weight loss. Patients are expected to benefit from improved obesity-related comorbidities, enhanced quality of life, and a durable weight loss profile. Confidentiality and Data Sharing All participant data will be de-identified and stored securely. Only authorized investigators will have access to the data. Individual participant data (IPD) will not be shared publicly due to privacy and institutional regulations but may be available upon reasonable request for meta-analyses with ethics approval. Study Significance This study represents a step toward personalized bariatric surgery. By objectively measuring bowel length and tailoring the bypass segment, surgeons can minimize variability and optimize outcomes. The use of a stapled anastomosis further standardizes the procedure, reducing technical variability. If successful, this tailored SADI-S approach could serve as a model for safe, effective, and individualized metabolic surgery, contributing valuable evidence toward standardization of limb length in malabsorptive procedures.